If you have a problem with your Toyota Hilux, and you can’t find out where it’s originating from, don’t get worried, we’re just in this article to help you find solutions to these problems. If in your situation, your Toyota Hilux stops while driving , you must be more than worried by this problem. In this guide, we will help you to find the cause of the problem. You will be delighted to learn, nevertheless, that a vehicle that stops while you are driving can provoke a lot of different problems, so try to check out all of them from the perspective of how your Toyota Hilux behaves when it dies while driving. To get this done, we will now list all the components that have been identified to be involved and the trigger of their failure when the Toyota Hilux dies while driving.
Toyota Hilux THAT shuts off ALTHOUGH DRIVING: THE PARTS CONCERNED
We will in fact help you with your research on the source of your Toyota Hilux that dies while driving. Examine all components that if damaged will be the trigger of the problem you are going through.
THE EGR VALVE
The EGR valve is one of the components that bring about a lot of hassle for drivers. Obviously, this valve has a habit of clogging up the more time passes or caused by a “quiet” driving of your Toyota Hilux. This can lead to poor exhaust gas diffusion and, when it is completely clogged, a loss of power and possibly stalling at idle. Examine this detailed guide to EGR valve problems for more information.
A GROUND WIRE OR ELECTRICAL HASSLE
Does your Toyota Hilux shuts off while driving? Don’t forget to check out your electrical unit, whether it’s a ground wire, for example, which can trigger a short circuit, or a fully damaged electrical circuit that can no longer carry electricity. This is one of the most difficult motives to detect… We encourage that you try to find a “burnt” part for the ground wire, which would present that an electric arc has created between a cable and the bodywork, nevertheless you will definitely have to contact a professional to fix this problem.
IDLE ACTUATOR
The purpose of this part is to control the engine idle speed of your Toyota Hilux. If your Toyota Hilux engine unit stops suddenly when you’re at a standstill, such as at a red light, verify the level of wear on your actuator.
THE FUEL PUMP
One of the most rational causes, without fuel, the engine stops running. Often, over the years, the fuel pump filter can become clogged or the fuel pump is weak and no longer pumping. Either way, your Toyota Hilux could get rid of while driving.
FUEL INJECTION SYSTEM
Same reflection as discovered before, nevertheless, in this situation it is the last phase of the fuel intake into the engine. Seized injectors, a defective injection pump or sensor and your Toyota Hilux can go out of service or completely disable your fuel injection. An injection problem will usually appear when the fuel injection is hot.
NEIMAN PROBLEM
A neiman, specifically concerning its ignition switch, will often trigger you trouble and trigger your Toyota Hilux to get rid of while driving. This element, which is necessary for starting your motor vehicle, also serves as an anti-theft protection, which will prevent your Toyota Hilux from running normally if it breaks down.
IGNITION COILS (PETROL ENGINE ONLY)
The penultimate most important explanation an Toyota Hilux stops while driving is the ignition coil. This source is just relevant for petrol cars since the engine runs by explosion and not by compression. In case your coils are too worn out, they will no longer spark. Look on that side.
BATTERY / ALTERNATOR
Finally, it is also possible to be the victim of a tired battery or a damaged alternator. In both situations, the lack of energy stored inside the battery will prevent your Toyota Hilux from running as it will no longer be able to power the most important parts of your engine unit.
If you need more guides on the Toyota Hilux, go to our Toyota Hilux category.
